船舶救生消防设备维护须知解析.docx
- 文档编号:14448400
- 上传时间:2023-06-23
- 格式:DOCX
- 页数:18
- 大小:27.48KB
船舶救生消防设备维护须知解析.docx
《船舶救生消防设备维护须知解析.docx》由会员分享,可在线阅读,更多相关《船舶救生消防设备维护须知解析.docx(18页珍藏版)》请在冰点文库上搜索。
船舶救生消防设备维护须知解析
船舶救生消防设备维护须知
Shiplife-savingfireequipmentmaintenanceInstruction
1.固定式气体(CO2)灭火系统保养须知
Fixedgas(CO2)fire-extinguishingsystemmaintenanceguidelines
1.1.适用范围:
有固定式气体(CO2)灭火系统船舶。
Applicablescope:
equippedthefixedgas(CO2)extinguishingsystemonboard.
1.2.保养负责人:
三副。
Maintenancesupervisor:
3/O
1.3.保养周期:
Maintenanceperiod:
1.3.1.每季度常规检查,三副与水手长共同检查,内容为站室钢瓶操纵装置、通风装置、通讯设备及声、光报警装置。
Routineexamination,tobecarriedoutby3/Oandbosun,itemsareasfollowcylindercontroldevice,ventilatingdevice,communicationsequipmentandsoundandlightalarmdevice.
1.3.2.所有管路每2年用压力0.5Mpa空气作畅通试验;每4~5年进行试验压力至少为0.7Mpa气密试验;瓶头阀至分配阀箱管段每8~10年进行压力为11.8Mpa液压试验;管路液压试验后,应将流体排除干净。
Allpipingtobecarriedouttheblowingofftestwith0.5Mpacompressedairevery2yearsinterval,airtightnesstesttobecarriedoutwith0.7Mpacompressedairevery4-5yearsinterval,hydraulictestofthepipebetweenthecylinderheadvalvesandthedistributingboxtobecarriedoutwith11.8Mpacompressedairevery4-5yearsinterval,pipinghydraulictest,theresiduesshouldbeexcludedcleanfluid.
1.3.3.每五年管系(自分配阀至喷头段)压力试验。
由三副负责,注意取得专业机构认可证明。
Everyfiveyearsthepiping(fromdistributingvalvetonozzlesection)pressuretested.3/Owillberesponsibleforit,payattentiontoobtainingprofessionalorganizationsrecognizedcertificate.
1.3.4.二氧化碳容器在20年后,每隔5年进行一次内部检查。
Dointernalexaminationforcarbondioxidecontainersonceevery5yearsafter20years.
1.3.5.瓶头阀应经液压试验,试验压力为24.5MPa。
Hydrostatictestofthecylindervalveshouldbecarriedout,andthetestpressureis24.5MPa.
1.4.固定式气体(CO2)灭火系统保养
Fixedgas(CO2)fireextinguishingsystemmaintenance
1.4.1.大型(CO2)灭火站:
Alarge(CO2)firestation:
1.4.1.1.灭火站应有明显红色标志,门上加锁,钥匙三副保管,备用钥匙大副保管,应急钥匙在灭火站附近封闭盒子内,盒子用玻璃盖,便于击碎取出钥匙,该钥匙盒应有明显大红色标志。
Thereshouldbeobviousredsigninfirestation,andthedoorshouldbelocked,the3/Okeepsthekey,thechiefofficerkeepsthefalsekey,theemergencykeyisstoredintheclosedboxnearbythefirestation,andtheboxislidedbyglasstotakeoutthekeyeasily,thekeyboxshouldhaveobviousbigredmarks.
1.4.1.2.灭火站内清洁干燥,照明充足并应设有应急照明和船舶电话(无电话时,进入人员应携带对讲机并预先约好联系人),通风良好,温度应在0~45℃之间,注意防冻与降温。
Thefirestationshoulebecleananddry,lightingadequateandbeequippedwithemergencylightingandmarinetelephone(personenteredshouldcarryintercomandappointcontactsinadvancewhenthereisnophone),wellventilatedandthetemperatureshouldbetween0-45℃,andpayattentiontofreezeandcooling.
1.4.1.3.站内不得堆放与本站无关杂物。
Theirrelevantsundryshouldnotbestackedwithinthestation.
1.4.1.4.站内应设有准确大型(CO2)系统图:
各分路阀、总阀、控制阀标牌清楚完好;开关标志明显;施放说明准确、简要;施放手柄与报警器(机舱内声、光报警三分钟)联动有效。
Thereshouldbealarge(CO2)systemdiagraminthesttation:
eachshuntvalve,mainvalve,controlvalvescutcheonshouldbeclearandintact,switchlogoisobvious;thedischargeintroductionsisaccurateandbriefly,thereleasehandleandalarm(soundandlightkeepalarmingthreeminutesintheengineroom)shouldbelinkageeffective.
1.4.2.钢瓶:
Cylinder:
1.4.2.1.钢瓶外观无锈、油漆完好。
Appearanceofcylindershouldbenorustandpaintintact.
1.4.2.2.钢瓶水压试验在有效期内,证书有效。
Keepthecertificatevalidandcylinderhydrostatictestwithintheperiodofvalidity.
1.4.2.3.钢瓶内灭火剂充装率不应大于0.67kg/l。
Thecylinderchargingratiooffireextinguishingagentshouldnotbegreaterthan0.67kg/l.
1.4.2.4.所有二氧化碳钢瓶每二年应进行称重检查(或液面测量)。
若每瓶CO2净重减少原重10%时,应予填充。
总减少量小于最大一个被保护舱室需要量5%时,可同意暂不充灌;但空瓶一经发现,应拆下试压并充灌。
Allcarbondioxidecylindersshouldundertakeweightinginspectioneverytwoyears(orliquidlevelmeasurement).IfeachbottleCO2netweightreducedto10%oftheoriginalweight,itistoberefilled.Whentotalreductionissmallerthan5%ofthemaximumprotectedcabinrequirement,itisallowednotfillingtemporary,buttheemptybottlewasoncefound,itistoberemovedandrefilledafterpressuretest.
检测应请专业单位进行,三副监测,证书交船长保管,公司机务部保管副本一份。
Weshouldaskprofessionalunittotest,thirdofficermonitoring,certificatekeptbythethecaptain,andcompanymaintenancedepartmentkeepacopyofthecertificate.
1.4.2.5.垂直放置,各瓶铡刀轴高度相等且处于同一垂直平面。
Placeinvertical,eachbottlepoleshaftheightisequalandinthesameverticalplane.
1.4.3.操纵装置:
Operatingdevice:
1.4.3.1.瓶头阀无松动、变形。
Bottleheadvalvewithoutloosing,deformation.
1.4.3.2.瓶头阀铰刀无断折缺损,刀处于退足状态,刀头与镀层膜片距离3mm。
Bottleheadvalvereamerwithoutbreakanddefects,knifeisfullyfolded,thereamerheadisapart3mmfromthecoatingdiaphragm.
1.4.3.3.瓶头阀手柄:
各手柄上拉索固定孔与铰刀铀之间距离相等,与铰刀轴连接牢固,止动螺钉深入铰刀轴且上紧,各手柄与重垂成60°,转动范围不少于120°,各手柄平行。
Bottleheadvalvehandle:
thedistancebetweenguyfixingholeoneachhandlesandreamershaftisequal,andthefixingholeslinkfirmwiththereamershaft,stopscrewin-depthofthereamershaftistightened,eachhandlewithheavyhangdowninto60°,thetwirlscopeisnotlessthan120°,andeachhandleisparallel.
1.4.3.4.控制钢索:
成水平直线,无拼接,无锈蚀、毛刺,连接牢固。
Controlthecablewire:
keephorizontal,withoutsplice,nocorrosionandburr,beimmobilityconcatenated.
1.4.3.5.导向滑轮:
底座牢固,无松动,转动灵活(注意加油)。
Leadingpulley:
baseisfirm,nolooseness,rotateeasily(noteoilit).
1.4.3.6.驱动气瓶:
压力充足,阀头刀活络有效,驱动气缸内活塞密封良好、活络有效。
Drivengascylinder:
thepressureissufficient,headofvalveknifeactivateeffectively,innerpistonofdrivencylindersealsgoodandmoveseffectively.
1.4.4.管系:
Pipesystem
1.4.4.1.总阀、分路阀、开关方向标志鲜明,阀开关活络。
Signofmainvalve,shuntvalve,switchdirectionshouldbedistinct,valveswitchshouldbeflexible.
1.4.4.2.喷嘴应为黄铜制品,防变形、防堵塞、雾化片完好。
Nozzleshouldbebrassproducts,preventdeformationandblocking,atomizationsliceisintact.
1.4.4.3.管道无严重锈蚀,红色油漆鲜明。
若须修理,只可用螺纹连接不可焊接,或整根换新。
Thereisnoseriouscorrosiononpiping,paintthepipewithbrightredpaint.Ifitneedtoberepaired,shouldonlybethreadedconnectionsorrenewed,unweldable.
1.5.保养记录:
Maintenancerecord:
1.5.1.三副应记录每个钢瓶水压试验期限,对不符合要求,应及时提请换新。
3/Oshallberecordedeachcylinderhydrostatictestperiod,whichisnotinconformitywithrequirements,shouldtimelychangenew.
1.5.2.每季度检查记入船舶维护检修记录表。
Quarterlyreviewtheshiprepairandmaintenancerecord.
1.5.3.每二年CO2瓶称重(液位测量)必须取得相应证明,由三副负责,并将称重报告交船长审核、保存。
WeightingCO2bottleseverytwoyears(liquidlevelmeasurement)mustobtaincorrespondingproof,itisinchargeofthirdofficer,andsenttheweightingreporttothecaptainforauditingandfiling.
1.5.4.所有检查、试压均由三副负责,结果由大副记入航海日志重大记事栏中,报机务部存档,并应记在船舶维护检修记录表。
Allinspection,testingareinthechargeofthirdofficer,theresultsshouldberecordedinthemajorchroniclecolumnoflog,senttothemaintenancedepartmentforfiling,andwritteninshipmaintenancerepairlogsheets.
1.6.证明:
Certification:
CO2钢瓶换新时,三副必须检验钢瓶上钢印,确认三个月内做过压力试验,并有瓶内灭火剂足够数量证明,否则退瓶。
WhenrenewtheCO2steelcylinders,thirdofficermustverifythesteelsealonthecylinder,confirmpressuretestinghasbeendonewithinthreemonths,andhavequantitycertificationofsufficientextinguisherinthecylinder,orrefundit.
2.手提式、推车式灭火器保养须知
Portable,carttypeextinguishermaintenanceguidelines
2.1.保养周期:
手提式灭火机(轻水泡沫)、推车式泡沫灭火器每三个月检查一次。
修船后大风浪之后和重大节假日之前,以及发生火警之后均应进行一次保养。
Maintenanceperiod:
checktheportableextinguisher(light-waterfoam),carttypefoamfireextinguishereverythreemonths.Maintainitonceaftership-repair,stormywaves,fireandbeforemajorholidays.
2.2.保养标准:
Maintenancestandard:
2.2.1.数量:
满足船级社规定要求。
Quantity:
meettheprescribedrequirementsofclassificationsociety.
2.2.2.存放:
位置及其编号应做到,标志清晰,有固定存放架,防止摇动倾斜和撞击。
周围通道畅通,以便提取使用,不应有妨碍提取之物。
防止过热或曝晒,泡沫灭火器防晒、防冻。
Storage:
positionanditsnumbersshouldbemarkedclearly,thereshouldbefixedstorageracktopreventshakentiltingandimpact.Itshouldbecleararoundthechannelinordertoextractanduse,thereshouldnotbeobjectsinterfereextraction.Preventoverheatingorsolarization,freezeandsolarizationshouldbepreventedforfoamfireextinguishersunscreen.
2.2.3.清洁:
无积灰及油污,外壳无锈斑,标志鲜明。
Cleaning:
noaccumulationsofdustandgreasydirt,shellwithoutrustyspot,andsignsaredistinct.
2.2.4.释放装置:
喷嘴畅通,保险销无锈,活络。
Releasedevice:
nozzleunblocked,Safetypinisflexiblewithoutrust.
2.2.5.灭火剂:
Extinguishant:
2.2.5.1.CO2灭火器净重不低于原标准90%,泡沫液在有效期内。
NetweightofCO2fireextinguisherisnotlessthan90%oftheoriginalstandard,foamfluidshouldbewithinthevalidperiod.
2.2.5.2.有压力表者,压力表指针不得低于绿色区域。
Forwhichequipmenthaspressuregauges,theindicatorshouldnotbelowerthanthegreenarea.
2.2.5.3.使用过灭火器,不论灭火剂是否用完,均应以新灭火器替换,或重新填充灭火剂。
Theusedfireextinguisher,nomatterwhetherthefire-extinguisherchemicalhasbeenrunout,shouldbereplacedwithnewfireextinguisherorrefilled.
2.2.6.保养卡完整,清洁,填写规范。
Maintenancecardsshouldbecomplete,clean,fillednormatively.
2.3.保养记录:
Maintenancerecord:
2.3.1.每只灭火器上保养记录卡,记录该灭火器历次检查日期,剂量及保养人。
Maintenancerecordcardoneachfireextinguisher,recordthefireextinguisherallpreviouscheckdates,doseandmaintenancepersononit.
2.3.2.保养日期,保养内容(换新,补充灭火剂,称重量等)保养人等情况由三副记入船舶维护检修记录表,作为安全管理记录并妥善保管。
Thesituationsofmaintenancedate,maintenancecontent(renew,supplementtheextinguisher,weightitetc.),maintenancepeopleetc.shouldberecordedonshipmaintenancerecordformbythirdofficer,keepitproperlyassecuritymanagementrecord.
2.4.检查:
Inspection:
2.4.1.各灭火器保养由三副监督,并按保养标准检查。
Thethirdofficershouldsupervisethefireextinguishermaintenanceandinspectthemaccordingtothemaintenancestandards.
2.4.1.1.清点数量,核对编号及位置。
Countquantity,checkthenumberandlocation.
2.4.1.2.统一检查贮存、外观、保养记录卡。
Uniformlycheckstorage,appearanceandmaintenancerecordcard.
2.4.1.3.抽查灭火剂量(手提或称量,查看压力表等)。
Selectivelyexaminefire-extinguishingdoses(portableorweighing,checkpressuregauge,etc.).
2.4.2.检查执行情况及检查结果,列入安全活动日项目之一。
Checktheperformanceandtestresults,listitinthesafetyCampaigndayitems.
3.常用消防防护装备保养须知
Com
- 配套讲稿:
如PPT文件的首页显示word图标,表示该PPT已包含配套word讲稿。双击word图标可打开word文档。
- 特殊限制:
部分文档作品中含有的国旗、国徽等图片,仅作为作品整体效果示例展示,禁止商用。设计者仅对作品中独创性部分享有著作权。
- 关 键 词:
- 船舶 救生 消防设备 维护 须知 解析